Phosphonic acid, dimethyl ester Safety Data Sheets
SAFETY DATA SHEETS
According to the UN GHS revision 8
SECTION 1: Identification
1.1 GHS Product identifier
| Product name | Dimethyl phosphonate |
|---|
1.2 Other means of identification
| Product number | - |
|---|---|
| Other names | dimethyl H-phosphonate; Dimethylfosfit; dimethyl hydrogen phosphonate |
1.3 Recommended use of the chemical and restrictions on use
| Identified uses | Intermediates,Lubricants and lubricant additives |
|---|---|
| Uses advised against | no data available |
1.4 Supplier's details
| Company | Echemi.com |
|---|---|
| Address | Echemi.com |
| Telephone | Echemi.com |
1.5 Emergency phone number
| Emergency phone number | Echemi.com |
|---|---|
| Service hours | Monday to Friday, 9am-5pm (Standard time zone: UTC/GMT +8 hours). |
SECTION 2: Hazard identification
2.1 Classification of the substance or mixture
Skin sensitization, Category 1
Germ cell mutagenicity, Category 2
Carcinogenicity, Category 2
Hazardous to the aquatic environment, long-term (Chronic) - Category Chronic 3
2.2 GHS label elements, including precautionary statements
| Pictogram(s) |   |
|---|---|
| Signal word | Warning |
| Hazard statement(s) | H317 May cause an allergic skin reaction H341 Suspected of causing genetic defects H351 Suspected of causing cancer H412 Harmful to aquatic life with long lasting effects |
| Precautionary statement(s) | |
| Prevention | P261 Avoid breathing dust/fume/gas/mist/vapours/spray. P272 Contaminated work clothing should not be allowed out of the workplace. P280 Wear protective gloves/protective clothing/eye protection/face protection/hearing protection/... P203 Obtain, read and follow all safety instructions before use. P273 Avoid release to the environment. |
| Response | P302+P352 IF ON SKIN: Wash with plenty of water/... P333+P317 If skin irritation or rash occurs: Get medical help. P321 Specific treatment (see ... on this label). P362+P364 Take off contaminated clothing and wash it before reuse. P318 IF exposed or concerned, get medical advice. |
| Storage | P405 Store locked up. |
| Disposal | P501 Dispose of contents/container to an appropriate treatment and disposal facility in accordance with applicable laws and regulations, and product characteristics at time of disposal. |
2.3 Other hazards which do not result in classification
no data available
SECTION 3: Composition/information on ingredients
3.1 Substances
| Chemical name | Common names and synonyms | CAS number | EC number | Concentration |
|---|---|---|---|---|
| Dimethyl phosphonate | Dimethyl phosphonate | 868-85-9 | 212-783-8 | 100% |
SECTION 4: First-aid measures
4.1 Description of necessary first-aid measures
If inhaled
Fresh air, rest. Refer for medical attention.
Following skin contact
First rinse with plenty of water for at least 15 minutes, then remove contaminated clothes and rinse again.
Following eye contact
First rinse with plenty of water for several minutes (remove contact lenses if easily possible), then refer for medical attention.
Following ingestion
Rinse mouth. Do NOT induce vomiting. Refer for medical attention .
4.2 Most important symptoms/effects, acute and delayed
no data available
4.3 Indication of immediate medical attention and special treatment needed, if necessary
Absorption, Distribution and Excretion
A study of dimethyl hydrogen phosphite (DMHP) by the National Toxicology Program (NTP) indicated that chronic administration by oral gavage resulted in an increased incidence of neoplastic lesions in the lungs and forestomachs of Fischer 344 rats but not in B6C3F1 mice. The current study was designed to evaluate the metabolic basis, if any, of this species selectivity by studying the metabolism and disposition of carbon-14-DMHP in the respective strains of rats and mice. Results of this study indicate that DMHP administered at a range of dose of 10-200 mg/kg was readily and near completely absorbed from the gastrointestinal tracts of rats and mice. DMHP-derived radioactivity was eliminated primarily as CO2 in the expired air, 44-57%, and urine, 28-49%, and very little was collected in feces, 1-2%, or as volatile organics, 2-3%. DMHP-derived radioactivity was widely distributed in tissues of rats and mice, with the highest concentrations observed in the liver, kidneys, spleen, lungs, and forestomach, and the lowest in brain, skeletal muscle, and adipose tissue. The disappearance of radioactivity from mouse tissues was approximately twice as rapid as from rat tissues. In vitro, DMHP was metabolized to formaldehyde by the microsomal fractions of liver, lungs, kidneys, forestomach, and glandular stomach. In vivo, DMHP was metabolized to the product of demethylation, monomethyl hydrogen phosphite (MMHP), which was excreted in urine. Results of this study indicate that the NTP carcinogenicity study with DMHP was carried out within the dose range in which the absorption, metabolism, and disposition of DMHP are linear in both species. Apparent species-dependent differences in the metabolism and disposition of DMHP are limited to the more rapid metabolism and elimination by the mouse. Therefore, the species-dependent variations in the carcinogenicity of DMHP are most likely attributable to factors other than metabolism and disposition.
SECTION 5: Fire-fighting measures
5.1 Suitable extinguishing media
Use foam, alcohol-resistant foam, carbon dioxide.
5.2 Specific hazards arising from the chemical
Combustible. Above 70°C explosive vapour/air mixtures may be formed.
5.3 Special protective actions for fire-fighters
Use foam, alcohol-resistant foam, carbon dioxide. In case of fire: keep drums, etc., cool by spraying with water. NO direct contact with water. Combat fire from a sheltered position.
SECTION 6: Accidental release measures
6.1 Personal precautions, protective equipment and emergency procedures
Personal protection: chemical protection suit and filter respirator for acid gases and vapours adapted to the airborne concentration of the substance. Do NOT let this chemical enter the environment. Cover the spilled material with inert absorbent. Collect leaking and spilled liquid in sealable containers as far as possible.
6.2 Environmental precautions
Personal protection: chemical protection suit and filter respirator for acid gases and vapours adapted to the airborne concentration of the substance. Do NOT let this chemical enter the environment. Cover the spilled material with inert absorbent. Collect leaking and spilled liquid in sealable containers as far as possible.
6.3 Methods and materials for containment and cleaning up
Collect and arrange disposal. Keep the chemical in suitable and closed containers for disposal. Remove all sources of ignition. Use spark-proof tools and explosion-proof equipment. Adhered or collected material should be promptly disposed of, in accordance with appropriate laws and regulations.
SECTION 7: Handling and storage
7.1 Precautions for safe handling
NO open flames, NO sparks and NO smoking. Above 70°C use a closed system and ventilation. Handling in a well ventilated place. Wear suitable protective clothing. Avoid contact with skin and eyes. Avoid formation of dust and aerosols. Use non-sparking tools. Prevent fire caused by electrostatic discharge steam.
7.2 Conditions for safe storage, including any incompatibilities
Dry. Store in an area without drain or sewer access. Separated from food and feedstuffs. See Chemical Dangers.
SECTION 8: Exposure controls/personal protection
8.1 Control parameters
Occupational Exposure limit values
MAK: carcinogen category: 3B
Biological limit values
no data available
8.2 Appropriate engineering controls
Ensure adequate ventilation. Handle in accordance with good industrial hygiene and safety practice. Set up emergency exits and the risk-elimination area.
8.3 Individual protection measures, such as personal protective equipment (PPE)
Eye/face protection
Wear safety goggles.
Skin protection
Protective clothing. Protective gloves.
Respiratory protection
Use ventilation, local exhaust or breathing protection.
Thermal hazards
no data available
SECTION 9: Physical and chemical properties and safety characteristics
| Physical state | Liquid |
|---|---|
| Colour | Mobile, colorless liquid |
| Odour | Mild odor |
| Melting point/freezing point | 29 deg C |
| Boiling point or initial boiling point and boiling range | 170-171ºC |
| Flammability | Combustible. |
| Lower and upper explosion limit/flammability limit | no data available |
| Flash point | 85 |
| Auto-ignition temperature | 237°C |
| Decomposition temperature | no data available |
| pH | no data available |
| Kinematic viscosity | 1.06 centistokes at 25 deg C |
| Solubility | Soluble in water; miscible with most organic solvents |
| Partition coefficient n-octanol/water | -1.2 |
| Vapour pressure | 1.5 mm Hg at 20 deg C |
| Density and/or relative density | 1.2 |
| Relative vapour density | 7.9 (Air = 1) |
| Particle characteristics | no data available |
SECTION 10: Stability and reactivity
10.1 Reactivity
Decomposes rapidly on heating. This produces toxic fumes including phosphorus oxides and phosphine. Decomposes on contact with moist air above 220°C. This produces phosphoric acid and methanol. The solution in water is a strong acid. It reacts violently with bases and is corrosive. Reacts violently with acids and oxidants.
10.2 Chemical stability
no data available
10.3 Possibility of hazardous reactions
The vapour is heavier than air.
10.4 Conditions to avoid
no data available
10.5 Incompatible materials
no data available
10.6 Hazardous decomposition products
When heated to decomposition it emits toxic fumes of /phosphorous oxides/.
SECTION 11: Toxicological information
Acute toxicity
- Oral: LD50 Mouse (male) oral 2815 mg/kg bw
- Inhalation: no data available
- Dermal: no data available
Skin corrosion/irritation
no data available
Serious eye damage/irritation
no data available
Respiratory or skin sensitization
no data available
Germ cell mutagenicity
no data available
Carcinogenicity
Evaluation: No epidemiological data relevant to the carcinogenicity of dimethyl hydrogen phosphite were available. There is limited evidence for the carcinogenicity of dimethyl hydrogen phosphite in experimental animals. Overall evaluation: Dimethyl hydrogen phosphite is not classifiable as to its carcinogenicity to humans (Group 3).
Reproductive toxicity
no data available
STOT-single exposure
The substance is irritating to the eyes and skin.
STOT-repeated exposure
The substance may have effects on the eyes. This may result in cataract.
Aspiration hazard
A harmful contamination of the air will be reached slowly on evaporation of this substance at 20°C; on spraying or dispersing, however, much faster.
SECTION 12: Ecological information
12.1 Toxicity
- Toxicity to fish: LC50; Species: Pimephales promelas (Fathead minnow); Conditions: freshwater; static; Concentration: 225000 ug/L for 4 days/formulated product
- Toxicity to daphnia and other aquatic invertebrates: no data available
- Toxicity to algae: no data available
- Toxicity to microorganisms: no data available
12.2 Persistence and degradability
AEROBIC: Dimethyl hydrogen phosphite, present at 100 mg/L, reached 48% of its theoretical BOD in 4 weeks using an activated sludge inoculum at 30 mg/L and the Japanese MITI test(1). However, biodegradation is not expected to be an important fate process(SRC) due to the hydrolysis of dimethyl hydrogen phosphite(2-5).
12.3 Bioaccumulative potential
Bioconcentration is not expected to be an important fate process(SRC) due to the rapid hydrolysis of dimethyl hydrogen phosphite(1-4).
12.4 Mobility in soil
Adsorption to soils or suspended solids is not expected to be an important fate process(SRC) due to the hydrolysis of dimethyl hydrogen phosphite(1-4).
12.5 Other adverse effects
no data available
SECTION 13: Disposal considerations
13.1 Disposal methods
Product
The material can be disposed of by removal to a licensed chemical destruction plant or by controlled incineration with flue gas scrubbing. Do not contaminate water, foodstuffs, feed or seed by storage or disposal. Do not discharge to sewer systems.
Contaminated packaging
Containers can be triply rinsed (or equivalent) and offered for recycling or reconditioning. Alternatively, the packaging can be punctured to make it unusable for other purposes and then be disposed of in a sanitary landfill. Controlled incineration with flue gas scrubbing is possible for combustible packaging materials.
SECTION 14: Transport information
14.1 UN Number
| ADR/RID: Not dangerous goods. (For reference only, please check.) | IMDG: Not dangerous goods. (For reference only, please check.) | IATA: Not dangerous goods. (For reference only, please check.) |
14.2 UN Proper Shipping Name
| ADR/RID: Not dangerous goods. (For reference only, please check.) | IMDG: Not dangerous goods. (For reference only, please check.) | IATA: Not dangerous goods. (For reference only, please check.) |
14.3 Transport hazard class(es)
| ADR/RID: Not dangerous goods. (For reference only, please check.) | IMDG: Not dangerous goods. (For reference only, please check.) | IATA: Not dangerous goods. (For reference only, please check.) |
14.4 Packing group, if applicable
| ADR/RID: Not dangerous goods. (For reference only, please check.) | IMDG: Not dangerous goods. (For reference only, please check.) | IATA: Not dangerous goods. (For reference only, please check.) |
14.5 Environmental hazards
| ADR/RID: No | IMDG: No | IATA: No |
14.6 Special precautions for user
no data available
14.7 Transport in bulk according to IMO instruments
no data available
SECTION 15: Regulatory information
15.1 Safety, health and environmental regulations specific for the product in question
| Chemical name | Common names and synonyms | CAS number | EC number |
|---|---|---|---|
| Dimethyl phosphonate | Dimethyl phosphonate | 868-85-9 | 212-783-8 |
| European Inventory of Existing Commercial Chemical Substances (EINECS) | Listed. | ||
| EC Inventory | Listed. | ||
| United States Toxic Substances Control Act (TSCA) Inventory | Listed. | ||
| China Catalog of Hazardous chemicals 2015 | Not Listed. | ||
| New Zealand Inventory of Chemicals (NZIoC) | Listed. | ||
| Philippines Inventory of Chemicals and Chemical Substances (PICCS) | Listed. | ||
| Vietnam National Chemical Inventory | Listed. | ||
| Chinese Chemical Inventory of Existing Chemical Substances (China IECSC) | Listed. | ||
| Korea Existing Chemicals List (KECL) | Listed. | ||
SECTION 16: Other information
Information on revision
| Creation Date | July 15, 2019 |
|---|---|
| Revision Date | July 15, 2019 |
Abbreviations and acronyms
- CAS: Chemical Abstracts Service
- ADR: European Agreement concerning the International Carriage of Dangerous Goods by Road
- RID: Regulation concerning the International Carriage of Dangerous Goods by Rail
- IMDG: International Maritime Dangerous Goods
- IATA: International Air Transportation Association
- TWA: Time Weighted Average
- STEL: Short term exposure limit
- LC50: Lethal Concentration 50%
- LD50: Lethal Dose 50%
- EC50: Effective Concentration 50%
References
- IPCS - The International Chemical Safety Cards (ICSC), website: http://www.ilo.org/dyn/icsc/showcard.home
- HSDB - Hazardous Substances Data Bank, website: https://toxnet.nlm.nih.gov/newtoxnet/hsdb.htm
- IARC - International Agency for Research on Cancer, website: http://www.iarc.fr/
- eChemPortal - The Global Portal to Information on Chemical Substances by OECD, website: http://www.echemportal.org/echemportal/index?pageID=0&request_locale=en
- CAMEO Chemicals, website: http://cameochemicals.noaa.gov/search/simple
- ChemIDplus, website: http://chem.sis.nlm.nih.gov/chemidplus/chemidlite.jsp
- ERG - Emergency Response Guidebook by U.S. Department of Transportation, website: http://www.phmsa.dot.gov/hazmat/library/erg
- Germany GESTIS-database on hazard substance, website: http://www.dguv.de/ifa/gestis/gestis-stoffdatenbank/index-2.jsp
- ECHA - European Chemicals Agency, website: https://echa.europa.eu/
Other Information
Do NOT use in the vicinity of a fire or a hot surface, or during welding.
Disclaimer: The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. The information in this document is based on the present state of our knowledge and is applicable to the product with regard to appropriate safety precautions. It does not represent any guarantee of the properties of the product. We as supplier shall not be held liable for any damage resulting from handling or from contact with the above product.
Phosphonic acid, dimethyl ester is included in Inorganic Acid Esters category. See more Phosphonic acid, dimethyl ester price and marketing trends
Related Products
Industry News
More Safety Data Sheets